Go to advanced search

by misterbleepy
Wed Sep 11, 2019 2:03 pm
Forum: Batteries and Battery Management
Topic: my 2013 Peugeot iOn will not charge :(
Replies: 12
Views: 404

Re: my 2013 Peugeot iOn will not charge :(

kiev wrote:i took my car to the dealer yesterday to request a new chargger under the extended warranty letter. They said OK, no charge, we'll get it ordered.

Result!

(and thanks for all of the advice so far)
by misterbleepy
Wed Sep 11, 2019 1:36 pm
Forum: Batteries and Battery Management
Topic: On-Board Charger (OBC) Warranty Extended!
Replies: 16
Views: 354

Re: my 2013 Peugeot iOn will not charge :(

Have you got more details about this warranty extension ? Onboard charger only or the whole HV system and/or battery ? US i-Miev only or i-Miev world wide ? Ion and C-Zero as well ? My guess is US Mitsubishi’s only at the moment. I spotted this thread immediately before I started opening up my Ion ...
by misterbleepy
Wed Sep 11, 2019 6:35 am
Forum: Batteries and Battery Management
Topic: my 2013 Peugeot iOn will not charge :(
Replies: 12
Views: 404

Re: my 2013 Peugeot iOn will not charge :(

While I track down replacement caps, and try an source the relevant fuse, does anyone have any tips on replacing the existing capacitors (or rather their remains) without removing the circuit board from the casing? I was thinking I could carefully remove the remnants of the caps while leaving their ...
by misterbleepy
Tue Sep 10, 2019 6:53 am
Forum: Batteries and Battery Management
Topic: my 2013 Peugeot iOn will not charge :(
Replies: 12
Views: 404

Re: my 2013 Peugeot iOn will not charge :(

ok, I left the coolant where it belongs, and have managed to access the OBC boards and the fuse in the MCU. Photos later, but the only damage I can see is one of the 2 blue snubber caps is split, and there’s a very small amount of discolouring on the potting compound immediately next to the 2 capaci...
by misterbleepy
Tue Sep 10, 2019 4:24 am
Forum: Batteries and Battery Management
Topic: my 2013 Peugeot iOn will not charge :(
Replies: 12
Views: 404

Re: my 2013 Peugeot iOn will not charge :(

I finally have some time to look further into this - I have a question - if I’m just going to take a look at the boards in-situ, do I need to drain the cooling system?
I will be removing the left seat and then pulling the service plug.
by misterbleepy
Mon Sep 02, 2019 11:21 am
Forum: Batteries and Battery Management
Topic: my 2013 Peugeot iOn will not charge :(
Replies: 12
Views: 404

my 2013 Peugeot iOn will not charge :(

So after having an instance of my car not charging due to the shift display not showing P, which was rectified by giving the shift leader a good ”stir”, I now have a more persistent case of the car being unable to charge (in the UK, so L2 240v charging). Symptoms: Charge seems to initiate as normal,...
by misterbleepy
Wed Aug 28, 2019 5:47 am
Forum: Batteries and Battery Management
Topic: Troubleshooting and repair for On-board Charger (OBC), DC-DC Converter
Replies: 413
Views: 67963

Re: Troubleshooting and repair for On-board Charger (OBC), DC-DC Converter

Yes. Look under the back of the car on the left hand side of the gearbox near the driveshaft and you can't miss it - give the pivot points and ball joints for the bowden cable levers a dose of spray grease and it should be fine after working the gear lever from one end to another. Thanks - somethin...
by misterbleepy
Mon Aug 26, 2019 9:54 am
Forum: Batteries and Battery Management
Topic: Troubleshooting and repair for On-board Charger (OBC), DC-DC Converter
Replies: 413
Views: 67963

Re: Troubleshooting and repair for On-board Charger (OBC), DC-DC Converter

Another thing I would check is to make sure the gear lever is properly engaging in park mode and doesn't feel "springy". If it doesn't fully engage in park this will cause the P to flash on the dashboard when the key is on and the car also will not charge. I've had that problem before too...
by misterbleepy
Thu Mar 28, 2019 4:50 am
Forum: Off Topic
Topic: Thailand
Replies: 5
Views: 2282

Re: Thailand

that's an "i", not an i-MiEV.
Nice wheels though.

Go to advanced search